Second Generation PFBC Systems R and D - Phase 2 and Phase 3. Monthly Technical Report, 08 PDF Download
Are you looking for read ebook online? Search for your book and save it on your Kindle device, PC, phones or tablets. Download Second Generation PFBC Systems R and D - Phase 2 and Phase 3. Monthly Technical Report, 08 PDF full book. Access full book title Second Generation PFBC Systems R and D - Phase 2 and Phase 3. Monthly Technical Report, 08 by . Download full books in PDF and EPUB format.
Author:
Publisher:
ISBN:
Category :
Languages : en
Pages : 6
Get Book Here
Book Description
When DOE funds were exhausted in March 1995, all Phase 2 activities were placed on hold. In February 1996 a detailed cost estimate was submitted to the DOE for completing the two remaining Phase 2 Multi Annular Swirl Burner (MASB) topping combustor test campaigns; in August 1996 release was received from FETC to proceed with the two campaigns to: (1) test the MASB at proposed demonstration plant full to minimum load operating conditions; (2) identify the lower oxygen limit of the MASB; (3) demonstrate natural gas to carbonizer fuel gas switching; and (4) demonstrate operation with low temperature compressor discharge air rather than high temperature ((almost equal to) 1,600 F) vitiated air. The 18 in. MASB was last tested at the University of Tennessee Space Institute (UTSI) in a high-oxygen configuration and must be redesigned/modified for low oxygen operation. A second-generation PFB combustion plant incorporating an MASB based topping combustor will be constructed at the City of Lakeland's McIntosh Power Plant under the US DOE Clean Coal V Demonstration Plant Program. This plant will require the MASB to operate at oxygen levels that are lower than those previously tested. Preliminary calculations aimed at defining the operating envelope of the demonstration plant MASB have been completed. Phase 3--Commercial plant design update: The Second-Generation PFB Combustion Plant conceptual design prepared in 1987 is being updated to reflect the benefit of pilot plant test data and the latest advances in gas turbine technology. The updated plant is being designed to operate with 95% sulfur capture and a single Westinghouse 501G gas turbine. The 1987 study investigated two coal feeding arrangements, e.g., dry and paste feed. Paste feeding resulted in a lower cost of electricity. Paste, however, increases the water content of the carbonizer generated syngas; this increases the equilibrium partial pressure of hydrogen sulfide gas over calcium oxide/calcium carbonate and thereby reduces the carbonizer sulfur capture efficiency. Recognizing that the carbonizer and the CPFBC work together to control the plant overall sulfur capture efficiency, the higher CPFBC efficiency can compensate for the carbonizer's lower sulfur capture efficiency depending upon the amount of coal and/or char being fed to each unit. Since the latter are determined by the overall plant heat and material balance, they prepared a balance for each feed case to enable selection of the plant coal feed system.
Author:
Publisher:
ISBN:
Category :
Languages : en
Pages : 6
Get Book Here
Book Description
When DOE funds were exhausted in March 1995, all Phase 2 activities were placed on hold. In February 1996 a detailed cost estimate was submitted to the DOE for completing the two remaining Phase 2 Multi Annular Swirl Burner (MASB) topping combustor test campaigns; in August 1996 release was received from FETC to proceed with the two campaigns to: (1) test the MASB at proposed demonstration plant full to minimum load operating conditions; (2) identify the lower oxygen limit of the MASB; (3) demonstrate natural gas to carbonizer fuel gas switching; and (4) demonstrate operation with low temperature compressor discharge air rather than high temperature ((almost equal to) 1,600 F) vitiated air. The 18 in. MASB was last tested at the University of Tennessee Space Institute (UTSI) in a high-oxygen configuration and must be redesigned/modified for low oxygen operation. A second-generation PFB combustion plant incorporating an MASB based topping combustor will be constructed at the City of Lakeland's McIntosh Power Plant under the US DOE Clean Coal V Demonstration Plant Program. This plant will require the MASB to operate at oxygen levels that are lower than those previously tested. Preliminary calculations aimed at defining the operating envelope of the demonstration plant MASB have been completed. Phase 3--Commercial plant design update: The Second-Generation PFB Combustion Plant conceptual design prepared in 1987 is being updated to reflect the benefit of pilot plant test data and the latest advances in gas turbine technology. The updated plant is being designed to operate with 95% sulfur capture and a single Westinghouse 501G gas turbine. The 1987 study investigated two coal feeding arrangements, e.g., dry and paste feed. Paste feeding resulted in a lower cost of electricity. Paste, however, increases the water content of the carbonizer generated syngas; this increases the equilibrium partial pressure of hydrogen sulfide gas over calcium oxide/calcium carbonate and thereby reduces the carbonizer sulfur capture efficiency. Recognizing that the carbonizer and the CPFBC work together to control the plant overall sulfur capture efficiency, the higher CPFBC efficiency can compensate for the carbonizer's lower sulfur capture efficiency depending upon the amount of coal and/or char being fed to each unit. Since the latter are determined by the overall plant heat and material balance, they prepared a balance for each feed case to enable selection of the plant coal feed system.
Author:
Publisher:
ISBN:
Category :
Languages : en
Pages :
Get Book Here
Book Description
Author:
Publisher:
ISBN:
Category :
Languages : en
Pages :
Get Book Here
Book Description
When DOE funds were exhausted in March 1995, all Phase 2 activities were placed on hold. In February 1996 a detailed cost estimate was submitted to the DOE for completing the two remaining Phase 2 Multi Annular Swirl Burner (MASB) topping combustor test campaigns; in August 1996 release was received from FETC to proceed with the two campaigns to: (1) test the MASB at proposed demonstration plant full to minimum load operating conditions; (2) identify the lower oxygen limit of the MASB; (3) demonstrate natural gas to carbonizer fuel gas switching; and (4) demonstrate operation with ''low temperature'' compressor discharge air rather than high temperature ((almost equal to) 1600 F) vitiated air. The 18 in. MASB was last tested at the University of Tennessee Space Institute (UTSI) in a high-oxygen configuration and must be redesigned/modified for low oxygen operation. A second-generation PFB combustion plant incorporating an MASB based topping combustor has been proposed for construction at the City of Lakeland's McIntosh Power Plant under the U.S. DOE Clean Coal V Demonstration Plant Program. This plant will require the MASB to operate at oxygen levels that are lower than those previously tested. Preliminary calculations aimed at defining the operating envelope of the demonstration plant MASB have been completed. The previous MASB tests have been performed at UTSI in a facility constructed to support the development of MHD power generation. Because of a loss of MHD funding, the UTSI facility closed October 1998. On February 2, 1999, Siemens Westinghouse proposed a 12-week study that would identify the cost of modifying the MASB for Lakeland low oxygen operation conditions and conducting tests 3 and 4 above at the Arnold Engineering Development Center (AEDC). On February 22, 1999, Siemens Westinghouse was given release to proceed with this study and results/recommendations were received on April 22, 1999. Siemens Westinghouse recommended a two-phase test effort. The first test effort would entail two 6-hour tests beginning November 1999 with the MASB operated with natural gas and ''cold'' compressor air. The MASB would be tested at full Lakeland pressure using the physical configuration planned for operation at lower pressure at Wilsonville in September 1999. As a result, the MASB test specimen would be a totally new unit (not a modification of a previously UTSI tested unit). The MASB would be installed in an existing AEDC test shell as shown in Fig. 1. Although the internals currently installed within the shell would have to be removed and reinstalled at the completion of the first test phase, no major facility modifications external to the shell are needed; this first test effort was estimated to cost $1.2 million. Although the second test effort was not the subject of this initial study, Siemens Westinghouse envisioned it being conducted in another AEDC test cell that is currently mothballed. The facility has been well preserved and it would be modified to permit syngas testing with both cold and hot vitiated air; these tests would not be conducted until the fall 2000 and were estimated to cost $3.2 million. Written questions were submitted to Siemens Westinghouse regarding their proposed test programs; their responses and cost estimates were transmitted to FETC on April 30, 1999. Review of the proposed programs by FETC revealed that they exceeded existing funding limits, and all further Phase 2 work was put on hold until additional funding becomes available.
Author:
Publisher:
ISBN:
Category :
Languages : en
Pages : 6
Get Book Here
Book Description
When DOE funds were exhausted in March 1995, all Phase 2 activities were placed on hold. In February 1996 a detailed cost estimate was submitted to the DOE for completing the two remaining Phase 2 Multi Annular Swirl Burner (MASB) topping combustor test campaigns; in August 1996 release was received from FETC to proceed with the two campaigns to: (1) test the MASB at proposed demonstration plant full to minimum load operating conditions; (2) identify the lower oxygen limit of the MASB; (3) demonstrate natural gas to carbonizer fuel gas switching; and (4) demonstrate operation with ''low temperature'' compressor discharge air rather than high temperature ((almost equal to)1600 F) vitiated air.
Author: A. Robertson
Publisher:
ISBN:
Category :
Languages : en
Pages : 0
Get Book Here
Book Description
Author:
Publisher:
ISBN:
Category : Government publications
Languages : en
Pages : 1104
Get Book Here
Book Description
Author:
Publisher:
ISBN:
Category : Science
Languages : en
Pages : 1030
Get Book Here
Book Description
Author:
Publisher:
ISBN:
Category : Power resources
Languages : en
Pages : 508
Get Book Here
Book Description
Author:
Publisher:
ISBN:
Category : Government reports announcements & index
Languages : en
Pages : 974
Get Book Here
Book Description
Author: World Bank
Publisher: World Bank Publications
ISBN: 9780821323953
Category : Business & Economics
Languages : en
Pages : 1422
Get Book Here
Book Description
The Republic of Korea's industrial policy has directed that nation's economy through nearly three decades of spectacular growth. But the authors of this paper maintain that this policy is showing signs of being outmoded. The time has come, the authors argue, for the Korean government to stop managing the economy's structural development and to redefine the responsibilities of business and government. Under this proposed compact, the allocation of resources would shift from the government to the private industrial and financial sectors. The transformation of the government bureaucracy from an ad hoc policy role to one of a transparent and predictable regulator is a key to the success of this undertaking. These new directions would present the government with enormous challenges. Greater competitive discipline and regulatory oversight would be required. While dealing with the complexities of the transition, the government would have to maintain macroeconomic stability and the momentum of savings and investment. For comparison, the study examines the industrial economies of France, Germany, Japan, and the United States, which underwent similar shifts.
